Audi A4, S4

since 2000 release

Repair and operation of the car

Audi A4, S4
+ Introduction
+ Governing bodies and methods of safe operation
- Current leaving and service
   Maintenance approach term indicator
   Schedule of routine maintenance
   General information on control
   Check of levels of liquids, control of leaks
   Check of a condition of tires and pressure in them. Designation of tires and disks of wheels. Rotation and replacement of wheels
   Replacement of motive oil and oil filter
   Checks of brake system. Adjustment of the parking brake
   Check of fuel system
   Check of a state and replacement of hoses of a motive compartment, localization of leaks
   Check of a condition of ridge belts of the streaming drive of auxiliary units
   Check of functioning of the cooling system and frost resistance of cooling liquid
   Check of a condition of system of production of the fulfilled gases
   Check of level of oil of automatic transmission
   Visual control of a box of gear shifting and the main transfer on leaks, check of level and addition of oil
   Check of a state component of a suspension bracket and steering
   Check of a condition of protective covers of power shafts
   Check of level of liquid of system of hydrostrengthening of a wheel
   Check of the air conditioning system
   Greasing of limiters of doors, cylinders of locks, hook of a cowl, movable panel of the hatch of a roof
   Visual control of a seat belt and block of a safety cushion
   Check of operability of headlights and horn
   Check of a state, adjustment and replacement of brushes of screen wipers
   Check of a condition of the battery, care of it and charging
   Replacement of the battery of emergency supply of Telematik system
   Replacement of an element of the filter of air of salon / coal filter of purification of air
   Replacement of brake fluid
   Check and replacement of spark plugs. Check of a condition of high-voltage wires
   Replacement of an element of the air filter of the engine
   Replacement of the fuel filter
   Check of a state and tension of a gear belt
+ Engine
+ Cooling systems, heating and air conditioner
+ Power supply systems, release and decrease in toxicity of the fulfilled gases
+ Systems of electric equipment of the engine
+ Manual box of gear shifting
+ Automatic transmission
+ Coupling, power shafts and differential
+ Brake system
+ Suspension bracket and steering
+ Body
+ Onboard electric equipment


Types and volumes of the applied greasings and liquids

Do not allow children to operational materials. At their hit in the child's organism immediately address to the doctor.

Apply the materials recommended by the producer, it is a condition of implementation of guarantee certificates.

Motive oil



At service on flexible hours (Longlife)
  • Petrol engine

503 00 according to the VW specification

  • The diesel engine (without pump nozzles)

506 00 according to the VW specification

  • The diesel engine about the pump nozzles

506 01 according to the VW specification

At software maintenance to the tough schedule

  • Petrol engine
500 00, 501 01, 502 00 (models with a turbocompressor) according to the specification VW or SF, SG according to the API specification
  • The diesel engine (without pump nozzles)
505 00 according to the VW or CD specification according to the API specification
  • The diesel engine about the pump nozzles
505 01 according to the VW specification

Volume, when replacing together with an oil filter, l



L engine 1.6, 1.8, 1.9


Engine of 2.0 l


L engine 2.4, 2.5, 3.0


Engine of 4.2 l


RKPP and differential

Synthetic oil of the AUDI "G of 052 911 A" specification. Viscosity 75W 90 on SAE

Differential of all-wheel drive models with RKPP

1.5 l of VW/AUDI-G052 145 oil

Automatic transmission




0.8 l of synthetic oil of the AUDI "G 052 145" specification. Viscosity 75W 90 on SAE


1.3 oil l for AT Multitronic of the AUDI "G 052 190" specification

Brake fluid

1 l, FMVSS 116 DOT 4


G 002 000 liquid

Air conditioner

A2 G 052 300 oil (180±10 cmi), R134a coolant (480-530 gr.)

Cooling system

Mix of antifreeze and bezizvestkovy water


"G 012 A8D" (red color) or another, VW/AUDI-TL-774-D meeting standard, for example "Glysantin-Au-Protect/G30". It is allowed to apply "G12" (TL-VW-774-F) of lilac color. G12-lila antifreeze (lilac) can mix up with G12-rot antifreeze (red). On the 8-cylinder engine - only "G12 Plus"

Volume, during the replacing, l



4-cylinder engines


6-cylinder engines


8-cylinder engines


Composition of cooling liquid

Antifreeze share in cooling liquid for ensuring frost resistance



to -25 °C


to -35 °C


to -40 °C


Hinges of equal angular speeds

G 000 603, G 000 633 or G 000 605 greasing, depending on diameter of the hinge (address to materials of the Head Stsepleniye, power shafts and differential)

Greasing of runners of the panel of the hatch of a roof, loops of doors and cowl, cylinders of locks

Audi-G 052 778 A2

Greasing of loops of a trunk lid (model of 2002 vyp.)

Aerosol VW/AUDI G 000 115 A2 oil

Glass - and a faroomyvatel



Capacity of the tank, l

  • Models without faroomyvatel


  • Models with a faroomyvatel



Water in mix with summer "S" (1:100) or winter "W" a concentrate

Add stekloomyvayushchy means to water during the whole year for prevention of formation of stains. Choose composition of mix according to temperature of external air. Prepare mix in a separate vessel. Thanks to existence of heating of windscreen washer the concentration of mix providing frost resistance to -10 °C is sufficient.


Fuel tank



Capacity, l

70 (66 on models with the full drive)

Petrol models

Unleaded gasoline: AI-95/A-85 is not worse. Perhaps temporary use of unleaded gasoline is not worse than AI-91/A-82.5. Thus engine capacity will decrease a little, at increase in fuel consumption

Do not apply additive to fuel. They can result in the increased wear or damage of the engine.

Diesel models

Summer and winter diesel fuel

Do not apply ship (Marine Diesel Fuel), diesel fuel boiler, etc.

When using diesel fuel with the content of sulfur over 0.5%, make replacement of motive oil each 7500 km.

Winter fuel, provides normal working capacity to -20 °C.

Thanks to preliminary heating of fuel at the included system of heating of the car, the car on winter diesel fuel can be operated, as a rule, without refusals at a temperature of external air up to -25 °C.

Do not add gasoline to diesel fuel.

In case of use of summer diesel fuel, and also at a temperature of external air below -15 °C it is necessary to add certain, depending on temperature of external air quantity of means for improvement of fluidity or kerosene to fuel.

Composition of mix

Means for improvement of fluidity can be used also in combination with kerosene.

You can receive the certificate of funds for improvement of fluidity for HUNDRED.

Additive share taking into account temperature of external air has to be minimum.

The kerosene share in mix has to make no more than 50%.

Add additive to diesel fuel before loss of property of fluidity of diesel fuel owing to release of paraffin. Faults owing to release of paraffin can be rectified only heating of all power supply system.

Carry out mixing of diesel fuel with kerosene only in a fuel tank. For this purpose in a tank at first fill in kerosene, and then add diesel fuel.

After that the engine has to work some time in order that mix was distributed on all power supply system.

Spark plugs


Designation//Interelectrode gap, mm

Engine of 1.6 l (ALZ)

  • NGK

BKUR 6 ET-10//-or PFR 6Q//-

  • BERU

14 FGH-7 DTURX//1.0 or UXF 79//-

Engine of 1.8 l (AVJ)

F7 DPP 222 T//0.8
  • NGK
PFR 6Q//0.9 – 1.1
  • BERU
14 F-7 DPUR02//0.8 or UXF 79//-
Engines of 1.8 l (except AVJ)
NGK PFR 6Q//0.9 — 1.1
Engine of 2.0 l (ALT)
NGK BKUR 5 ET-10//1.0 - 1.1 or PFR 6Q//-
BERU 14 FGH-8 DTUR//1.0 or UXF 79//-
Engine of 2.0 l (AWA)


PZFR 5N-11 TG//0.9 - 1.1

Engine of 2.4 l (BDV)
BOSCH FGR 7 DQE 0//1.4
NGK BKR 6 EKUB//0.9 - 1.1
Engine of 3.0 l (ASN)
BOSCH FGR 7 DQE 0//1.4
NGK BKR 6 EKUB//0.9 - 1.1 or PFR 6U-11G//0.9 - 1.1
BERU 14 FGR-6 DDU//0.8
Engine of 4.2 l (BBK)
BOSCH FGR 7 DQE 0//1.6



Tires and disks

The used tires and pressure of air in tires of lobbies//back wheels

The demanded air pressure in tires is specified also in the plate on inside of a cover of the hatch of a fuel tank or at the rack basis In from the driver.



Partial loading

The summer

  • 195/65 R15 91H
  • 235/45 R17 93Y
  • 205/55 R16 91W

The winter

  • 195/65 R15 91T M+S


  • 205/55 R16 91H M+S


Full load
The summer
  • 195/65 R15 91H
  • 235/45 R17 93Y
  • 205/55 R16 91W
The winter
  • 195/65 R15 91T M+S
  • 205/55 R16 91H M+S

Sizes of disks/Depth of a press fitting, mm

The summer
  • 195/65 R15 91H
  • 235/45 R17 93Y
  • 205/55 R16 91W
The winter
  • 195/65 R15 91T M+S
  • 205/55 R16 91H M+S

Efforts of a tightening of threaded connections, Nanometer

The moments of an inhaling of fixture are given also in the text of the Head and on some illyustratsiyakh*.

* The moments of an inhaling highlighted in the text in bold type are subject to exact observance; the efforts which are not highlighted in bold type are given only approximately.



Spark plugs


Glow plugs


Drain stopper of oil of the pallet of a case

  • Petrol engine, diesel engine of 1.9 l


  • Diesel engine of 2.5 l


Stopper of RKPP gas station oil

  • CHECK POINT 012/01W/01A

Oil stopper of a case of the main transfer

Lock-nuts of tips of steering drafts 40

Bolts of wheels